We've grown a lot of land in the countrysideTractorRotators。
The ground, the ground, the earth, the earth, the garlic, all of itAgricultural machineryWork, save time and double efficiency。
But many of the old people work with their senses, their habits, their ways of doing things wrong, and they don't know it
It looks like normal work is done every day, and the machine is double-drive, fuel consumption is soaring, failure is constant and life is halved
Many of the new farm machines have been scrapped in two years, old machines have been built year after year, maintenance costs and oil costs have cost thousands more
Today, the three wrongs that have been used by the tractor + tiller, the worst of the machine, are the experiences of many years of combat conducted by master farmer
I don't knowOil savingsThe machine has been working for years
I. Directly pressurized gas, full-load hard dry (most damaging gearbox, bearings)
Most of the farmers are in first place:
It's on fire, it's on the gas, it's on the ground
It's the worst agricultural machine, the most expensive habit
The machine was parked all winter and all night, and the oil was revolving back to the shell, and the gears and bearings were dry。
It's not fully lubricated. It's full of hard and hard tillage. The gears are pressed in an instant. Dry frictions
Hazard
One, the new machine is fast old, the noise is high, the vibrations are strong
2 yearly breakdowns and frequent maintenance
It's the same place. More oil than anyone else
Operation correctly
Weaknesses are preheating for 3 to 5 minutes after the start of the cold car, with small oil doors running in the air, allowing oil to be fully lubricated with gear components, then gradually increasing the gas doors and downside operations
Get the machine back to work
Ii. Turning or not taking up a tiller, turning hard with a knife (most destructive axe, blade blade)
A lot of old people are taking time, turning around, turning around, moving around, never carrying a tiller, just taking a slash and grinding
This is the most common and deadly operational error in the countryside
The slashing blades are buried deep in the ground, and the resistance is so great that the force turns will cause:
Blade axle deformed, blade fractured, half-axis distorted
The longer the machine works, the deeper it goes, the deeper it goes, the more it goes, the more it goes, the more it goes, the more it goes, the more it goes, the more it goes, the more it goes, the more it goes
Operation correctly
The field turns, turns around and moves. You have to lift the tiller, get the blade out of the ground, and then turn
Looks like another little move, saving hundreds of maintenance bills a year
Iii. Direct de-fire at the end of the operation and never clear mud and weed (the most rusty, the most calcator)
Home from the dry season, many of the old people stopped and left。
The tiller is covered in mud, entangled in grass, straw, weed, never cleaned
Hide harm
1, wet mud covered with blades, bearings, long-term humid rust, cut
Two, weed-to-kill blade. Next time, we'll start with a lot of resistance
Three, mud plate strangulation, sharpening blades, shattering balance
The harder it gets to start, the more it gets to vibrate, the more the small problems of chronic failure to clean up have accumulated into trouble
Operation correctly
Two steps must be taken each day:
One, a moment of glitch, and shake the dirt
Artificial cleaning of axle weeds, slabs, and keeping the blade clean
Clean agricultural machinery, not only durable, but smoother and more fuel-efficient
Iv. Old farm machineryMaintenanceSave your money
The cold car is drying the most and is vulnerable with a knife。
Mud grass does not clean up rust and bad habits increase maintenance costs。
Pre-heat lifts were cleared and less oil was saved。
V. 3 additional money-saving techniques for agricultural machines (agricultural households)
1. No overloading of deep tillage: hard, wasteland step by step, no one-time drying of the deepest slot to prevent vehicle strangulation。
Wetland is not dry in the rain: the resistance of mud wetland is multiplying, and it is extremely stifling, disabling and expensive。
3. Long-term parking of oil and electricity: idle in autumn and winter, water purification, rustproofing of electricity, fire in the following year。
Summary
Rural agro-machines are unsustainable, fuel-intensive, expensive to repair, 80 per cent of which are not of poor quality and are the result of man-made operating habits
Change: three major mistakes: cold-car drying, knife turns, mud parking, machine failure rate reduced directly by half, fuel savings, savings, maintenance savings, one agricultural machine used for many years
Do you have a habit of turning around with knives and putting out the fire
